• Non ci sono risultati.

CARATTERISTICHE CHIMICO – FISICHE DEL FLUIDO IDRAULICO

N/A
N/A
Protected

Academic year: 2021

Condividi " CARATTERISTICHE CHIMICO – FISICHE DEL FLUIDO IDRAULICO "

Copied!
6
0
0

Testo completo

(1)

APPENDICE A

CARATTERISTICHE CHIMICO – FISICHE DEL FLUIDO IDRAULICO

SECTION I - Material Identity

Hydraulic Fluid Petroleum Base Fluid

Part Name Number/Trade MIL-H-5606 B (1) HYD FLUID MLS 89-10,A 0600

SECTION II - Physical/Chemical Characteristics

Specification Number MIL-H-5606B Specification Type/Grade/Class NONE

Hazard Storage Compatibility Code

F8

Net Propellant Weight (Ammo) N/R

Appearance/Odor RED,OILY LIQUID-PETROLEUM ODOR

Boiling Point 347F,175C

Melting Point UNKNOWN

Vapor Pressure <0.01 MMHG

Vapor Density >1

Specific Gravity 0.836 [Kg/m

3

]

(2)

Specific Heat 2092.19 [J/Kg·°C]

Thermal Conductivity 0.08 [Btu/(hr)·(ft

2

)·(°F/ft)]

Thermal Expansion Coefficient 0.00036 °C

-1

Bulk Modulus 270000 psi

Molecular Viscosity 0.02758 Pa·s Viscosity Temperature

Coefficient

0.645

Decomposition Temperature UNKNOWN

Evaporation Rate UNKNOWN

Solubility in Water NEG.

Percent Volatiles by Volume NIL.

Chemical pH N/R

Corrosion Rate UNKNOWN

Container Pressure Code 4

Temperature Code 8

Product State Code L

SECTION III – Fire and Explosion Hazard Data

Flash Point 225 °F

Flash Point Method UNKNOWN

Lower Explosion Limit UNKNOWN

Upper Explosion Limit UNKNOWN

Fire Point 275 °F

Autogenous Ignition Temperature 700 °F

Extinguishing Media WATER FOG, FOAM, DRY

CHEMICAL/CARBON

(3)

DIRECT STREAM OF WATER.

PRODUCT WILL FLOAT &

CAN BE REIGNITED Special Fire Fighting Procedures DO NOT ENTER ANY

ENCLOSED OR CONFINED AREA WITHOUT PROPER PROTECTIVE EQUIPMENT AND NIOSH-APPROVED SELF-CONTAINED BREATHING APPARATUS Unusual Fire/Explosion Hazards WILL RELEASE FLAMMABLE

VAPORS WHICH CAN BURN IN OPEN OR BE EXPLOSIVE IN CONFINED SPACES IF EXPOSED TO SOURCE OF IGNITION

SECTION IV - Reactivity Data

Stability YES

Stability Conditions to Avoid HIGH HEAT, FLAMES, SPARKS, OTHER SOURCES OF IGNITION Materials to Avoid STRONG OXIDIZING AGENTS Hazardous Decomposition Products CARBON MONOXIDE, CARBON

DIOXIDE, ASPHYXIANTS Hazardous Polymerization NO

Polymerization Conditions to Avoid

NOT RELEVANT

LD50 - LD50 Mixture TLV FOR OIL MIST IS 5 MG/M3

(4)

SECTION V - Health Hazard Data

Route of Entry: Skin NO Route of Entry: Ingestion NO Route of Entry: Inhalation NO Health Hazards - Acute and

Chronic

TARGET ORGANS:EYES, SKIN.

ACUTE- ORAL:NOT EXPECTED TO CAUSE ANY ILL EFFECTS EXCEPT IN VERY SENSITIVE PERSONS.

INHALE:NO SIGNIFICANT ADVERSE HEALTH EFFECTS ARE EXPECTED TO OCCUR ONSHORT TERM

EXPOSURE. EYE/SKIN:NO ILL EFFECTS EXCEPT IN VERY SENSITIVE INDIVIDUALLS.

CHRONIC- MAY CAUSE MILD IRRITATION & INFLAMMATION Symptoms of Overexposure MILD IRRITATION

Medical Cond. Aggrevated by Exposure

PERSONS WITH PRE-EXISTING SKIN DISORDERS MAY BE MORE SUSCEPTIBLE TO THE EFFECTS OF THIS PRODUCT

Emergency/First Aid Procedures CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:FLUSH WITHWATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WIPE

EXCESS. WASH SKIN WITH SOAP &

WATER. INHALED:REMOVE TO

FRESH AIR. PROVIDE CPR/OXYGEN

IF NEEDED.ORAL:DO NOT INDUCE

VOMITING. CALL A PHYSICIAN

(5)

SECTION VI - Precautions for Safe Handling and Use

Steps if Material Released/Spilled

ELIMINATE SOURCES OF IGNITION.

STOP LEAK. DIKE SPILLS. USE PUMP TO TRANSFER SPILLS TO CONTAINER FOR DISPOSAL.

REMAINING LIQUID/SMALL SPILLS CAN BE TAKEN UP ON SAND, CLAY, EARTH & SHOVELD INTO

CONTAINERS. PREVENT RUN-OFF TO ENTER WATERWAYS

Neutralizing Agent NOT RELEVANT

Waste Disposal Method DISPOSE OF IN AN APPROPRIATE DISPOSAL FACILITY INCOMPLIANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS. THIS PRODUCT IS AN OIL. SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE A SHEEN MUST BE REPORTED TO THE NRC, 800-424-8802

Handling and Storage Precautions

STORE IN COOL, DRY, VENTILATED PLACE AWAY FROM EXCESSIVE HEAT, FLAMES AND STRONG OXIDIZERS.

KEEP OUT OF REACH OF CHILDREN Other Precautions AVOID CONTACT WITH EYES AND

SKIN. WASH THOROUGHLY AFTER

HANDLING. LAUNDER CLOTHING

BEFORE REUSE. AVOID INHALING

MISTS. EMPTY CONTAINERS OF THIS

PRODUCT MAY BE HAZARDOUS DUE TO

THE RETENTION OF RESIDUES. DO

NOT HEAT ABOVE FLASH POINT

(6)

SECTION VII - Control Measures

Respiratory Protection NONE. IF TLV EXCEED, WEAR A NIOSH-APPROVED SELF CONTAINED BREATHING APPARATUS

Ventilation LOCAL EXHAUST FAN IS RECOMMENDED TO MAINTAIN CONCENTRATION OF OIL MIST IN AIR BELOW RECOMMENDED TLV

Protective Gloves NITRILES RECOMMENDED

Eye Protection SAFETY GOGGLES/FACE SHIELD Other Protective Equipment EYE WASH STATION AND SAFETY

SHOWER. INDUSTRIAL-TYPE WORK CLOTHING AND APRON AS REQUIRED Work Hygenic Practices OBSERVE GOOD PERSONAL HYGIENE

PRACTICES AND RECOMMENDED

PROCEDURES. DISCARD CONTAMINATED LEATHER GLOVES AND SHOES

SECTION VIII - Label Data

Protect Eye YES

Protect Skin YES

Protect Respiratory NO Chronic Indicator UNKNOWN

Contact Code SLIGHT

Fire Code UNKNOWN

Health Code UNKNOWN

React Code UNKNOWN

Riferimenti

Documenti correlati

It could be obtained reducing the mean radiant temperature (by using night cooling coupled with high thermal capacity) and increased air speed. Natural ventilation

While Italy has been among the first energy markets to achieve grid- and fuel parity, many more have followed, and more are expected to follow as the cost of the electricity pro-

showed that right ventricular apical (RVA) pacing causes abnormal contrac- tion patterns due to abnormal activation of the left ventricle during RVA pacing compared to normal

In order to determine the intrinsic corrosion of the carbon support in the absence of platinum, the dependence of the ionic mass current for mass 44 on the potential for a

2 it is possible to remark that in case of weak anti- saturation action, a high input mass flow is generated because of a small value of the elements... of matrix Q which

The WHO justly maintains that health authorities must develop a risk communication strategy, in order to avoid panic and behaviour that might worsen the pandemic, at any level

L’OMS sostiene, a ragione, che per evitare il panico e per evitare comportamenti che favoriscono la pandemia, a ogni livello – globale, regionale, nazionale, locale – le

As far as public transport in the city, it is important to reduce the number of private cars, to increase the taxi numbers and public transport means, possibly electric